Welcome, Guest

Author Topic: Mercury Outboard - Four Stroke  (Read 3650 times)

Offline rail

  • House Bee
  • **
  • Posts: 240
  • Gender: Male
Mercury Outboard - Four Stroke
« on: December 31, 2011, 09:51:54 AM »
My 15hp, four stroke, outboard will not idle unless the choke is engaged. Any other four stroke outboard owners with the same problem? :(
Sirach

Offline Shanevrr

  • Field Bee
  • ***
  • Posts: 507
  • Gender: Male
Re: Mercury Outboard - Four Stroke
« Reply #1 on: December 31, 2011, 11:24:25 PM »
sounds like lack of fuel,  clogged filter,  carb gummed up from crappy fuel.  Can you take carb bowl off and spray carb cleaner through needle.  Remove float, just dont lose the little pin that holds float in place
www.Valleybeesupply.com
"A responsible beekeeper is a successful one"
Shane C.

Offline Sundog

  • House Bee
  • **
  • Posts: 313
  • Gender: Male
Re: Mercury Outboard - Four Stroke
« Reply #2 on: January 01, 2012, 12:03:11 AM »
Vacuum leak?

Offline rbinhood

  • House Bee
  • **
  • Posts: 278
  • Gender: Male
Re: Mercury Outboard - Four Stroke
« Reply #3 on: January 01, 2012, 10:17:29 AM »
Diaphragm in your fuel pump has a small hole in it.
Only God can make these two things.....Blood and Honey!

Offline AllenF

  • Galactic Bee
  • ******
  • Posts: 8192
  • Gender: Male
Re: Mercury Outboard - Four Stroke
« Reply #4 on: January 02, 2012, 09:00:13 AM »
Have you been running pure gas or corn gas in it?

Offline rail

  • House Bee
  • **
  • Posts: 240
  • Gender: Male
Re: Mercury Outboard - Four Stroke
« Reply #5 on: January 02, 2012, 10:14:50 AM »
Have you been running pure gas or corn gas in it?

The first two hours on the engine was with 10% corn gas! Just switched to pure gas and it idles a little better now.

Seems there has been issues with the new four stroke outboards and ethanol fuel! :-x
Sirach

Offline AllenF

  • Galactic Bee
  • ******
  • Posts: 8192
  • Gender: Male
Re: Mercury Outboard - Four Stroke
« Reply #6 on: January 02, 2012, 10:20:44 AM »
I just put my small chain saw in the shop because of ethanol.    One day it would not hit but half a lick and when I let off the throttle, it died and would not fire again.   Don't let that stuff sit for more than a couple of months.   

Offline don2

  • Doak
  • House Bee
  • **
  • Posts: 393
  • Gender: Male
Re: Mercury Outboard - Four Stroke
« Reply #7 on: February 26, 2013, 10:28:34 PM »
Any thing you have that don't get cranked up and run at least once a week, "DON'T" use corn sipping s in it. Been there, done that. don2

Offline Nimrod

  • New Bee
  • *
  • Posts: 13
Re: Mercury Outboard - Four Stroke
« Reply #8 on: April 04, 2013, 11:08:33 PM »
I have a new Merc 9.9 and I run reg. gas (not 10%) with Sea Foam added.  I have ran this mixture in all my other small engines and it has not failed.

Offline divemaster1963

  • Field Bee
  • ***
  • Posts: 635
  • Gender: Male
  • God Protect and watch over our sons and daughters.
Re: Mercury Outboard - Four Stroke
« Reply #9 on: April 04, 2013, 11:44:07 PM »
I'm a small engine mechanic.
 Gasohol draws moisture like a paper towel. never leave it in your engine more than a week without running it for at least 30 min. because it made from corn it also molds! It will turn the inside of the carburetor green and plug every hole in it. use green stabil with the gas. never buy more gasohol than you can use in a day. when you finish use your equipment run it dry and spray seafoam in the carb and cylinder.  do this and your equipment will last.


John

Offline AllenF

  • Galactic Bee
  • ******
  • Posts: 8192
  • Gender: Male
Re: Mercury Outboard - Four Stroke
« Reply #10 on: April 05, 2013, 07:02:05 AM »
Or make the drive over the state line to Alabama and buy pure gas.    :-D   I stocked up for spring on my last fishing trip.   

Offline RC

  • House Bee
  • **
  • Posts: 255
  • Gender: Male
Re: Mercury Outboard - Four Stroke
« Reply #11 on: April 05, 2013, 08:17:58 AM »
Dumping groceries in your gas is never a good idea.

Offline bailey

  • Field Bee
  • ***
  • Posts: 874
  • Gender: Male
Re: Mercury Outboard - Four Stroke
« Reply #12 on: April 05, 2013, 08:23:43 PM »
Just got my outboard out of the shop because of corn gas. 
Won't run it again!!!
most often i find my greatest source of stress to be OPS  ( other peoples stupidity )

It is better to keep ones mouth shut and be thought of as a fool than to open ones mouth and in so doing remove all doubt.

 

anything